Photo Album
Below are photos of the conversion in various states of completion. Click on any picture to get a larger version of the photo. A small explanation will be right below the larger picture.
Fiero on trail
On the way back from Las Vegas
Fiero on trail
On the way back from Las Vegas
Fiero next to solar panels
One of the PV arrays that use to power the house and the car
Paint splash mark
Are these splashed electrons??
8 inch electric motor
The Old 8 Inch Advanced DC Motor
9 inch electric motor on bench
The New 9 Inch Advanced DC Motor
Electric Motor coils
Armatures for DC Motors
Electric motor coils
Commutator of DC motor
Electric motor brush holder
Brushes on DC Motors
Cluch plate mount
9 inch Advanced DC motor with flywheel adapter mounted
Motor Cluch and Mount Plate
9 inch Advanced DC motor with transmission adapter and flywheel mounted
Motor Cluch and Mount Plate
9 inch Advanced DC motor with transmission adapter, flywheel and pressure plate installed
8 inch and 9 inch side by side
Old 8 inch motor (left) and new 9 inch motor (right)
Electric Motor installed in fiero
Looking down from above: 9 inch ADC motor mounted to Fiero 4 speed tranny
Electric Motor installed in fiero
9 inch ADC motor mounted to Fiero 4 speed
Electric Motor installed in fiero
Rear compartment of Fiero shows cross brace
Old 120 Volt Battery Charger
K & W Charger in front of Fiero
Old 120 Volt Battery Charger
K & W charger
Old 120 Volt Battery Charger
K & W charger
DC Raptor 600 Controller
DC Power Raptor 600
DC Raptor 600 Controller
Raptor mounts beneath car where fuel tank use to live
DC Raptor 600 Controller
Raptor lives in center tunnel where fuel tank use to be
Inductive coil for throtle
Throttle Pot for DC Power Raptor 600
DC/DC Converter 120 volts to 12 volts
Sevcon DC-DC converter for 12VDC. Mounted in Fiero where original accessory battery was mounted.
Front Battery Racks without batteries
Front Battery Pack Rack
Front Battery Racks with Batteries
Front Battery Pack
Front Battery Racks with Batteries
Front Battery Pack
Rear Battery Racks with Batteries
Rear battery pack when car was at 108 volt
Rear Battery Racks with Batteries
Rear battery pack when car was at 108 volt
Heater core conversion
Original heater core after removal of center
Heater core conversion
Original heater core after modification
Heater core conversion
Original heater core with new electric element installed
Heater core conversion
Original heater core with center removed to accept electric heater
Heater core conversion
Original Heater core with electric heater installed
Heater core conversion
Original heater core with electric heater installed
Heater core conversion
Under dash shot of new heater core reinstalled
Heater core conversion
Under dash shot of new heater core with cover off
Charge Port fuel door
Charging plug in fuel door
Vacuum Pump
Vacuum Pump and switch for brake assist
Fuse of main battery pack
Circuit Breaker mounted on side of center hump in Fiero
0000 Guage Welding Wire used on Battery Pack
4/0 Welding cable that wires entire car together
Blowable Fuse
Fuse
Blowable Fuse
Fuse
Contactor / Relay
Old style 500 Amp Contactor
Shunt
500 Amp Shunt
Tach Driver
K & W Tachometer drive
 
Last Updated: